2007 Rendezvous Glove Box Door Hinge Repair
I'm not a car mechanic. In Fact, I hate working on cars, but this about drove me over the edge. What a cheap piece of crap. The hinge breaks into two parts. The part still attached to the glove box I'll call the box hinge, and the part attached to the door is the door hinge.
1. Since the door is already broke, remove it with its door hinge and place it aside.
2. Also remove the glove box air filter door.
3. Remove four glove box screws, two at top, two bottom.
4. Remove the right side panel, pry out to release the corner closest to you. This takes some effort. A clip will be exposed. push right to release this clip. There are two more similar clips holding this panel. Pry to the right to finish panel Release.
5. Start pulling on the right side of the glove box to loosen and release its right clips.
6. Pull on the center of the glove box using the filter opening to release its left clips.
7. The glove box pulls straight out.
8. On the bottom of the box, remove the 5 rivets holding the box hinge to the glove box. This can be done by attaching vice grips to the back side of the rivet and drilling the head removing the rivets.
9. Separate the box hinge from the glove box.
10. Holding to door, you can now mate the two hinge parts together. Remember the smooth side of the door hinge mates with the underside of the Box hinge.
11. I used Gorilla duct tape. Apply sticky side to the door hinge and to the underside of the box hinge covering the rivet holes. Punch through the tape at the 5 rivet holes.
12. Fit the door to the box and close the door. Use five #8-32 , screws, nuts, washers and lock washers in place of the rivets and attach the box hinge to the glove box. In the end, the tape will attach to the top of door hinge and be wedged between the box hinge and the glove box.
13. You should have a working unit.
14. Instead of tape, you may use your own method to attach the two hinge parts. Or replace the hinge with a new one.